Best Grilled Cuban Pork Pressed Sandwiches Recipes

GRILLED CUBANO SANDWICH

Steps:

• Cut the pork tenderloin in half crosswise with a sharp knife, creating two 5-inch-long pieces. Make a vertical cut down the middle of each piece, about 3/4 of the way through. Open the pieces like a book. Lay them cut-side down on a piece of plastic wrap, cover with another piece and use a meat mallet to lightly pound the pork to about 1/2 inch thick.
• Add the pork, 1/4 cup of the yellow mustard, olive oil, pickle brine and garlic to a quart- or gallon-size resealable bag. Close the bag, and rub the marinade into the pork. Let sit at room temperature for 30 minutes.
• Meanwhile, prepare a grill or large grill pan for medium-high heat.
• Once the pork has marinated for 30 minutes, transfer it to a plate, shaking off any excess marinade. Lightly oil the grill grates with vegetable oil. Sprinkle both sides of the pork liberally with salt and pepper, and grill until charred on both sides, 4 to 5 minutes per side for medium doneness. Transfer the pork a cutting board, and let it rest for 5 minutes. Reduce the grill heat to medium. Slice the pork across the grain into 1/8-inch-thick slices, and season lightly with salt and pepper.
• Brush the outside of the Cuban loaf with the butter, and lay the loaf halves cut-side up on a very long piece of aluminum foil. Mix the remaining tablespoon yellow mustard with the mayonnaise, and slather the mixture onto both pieces of bread. Layer the ham, pickles, pork and Swiss cheese on one half of the bread. Top with the other half, and wrap the sandwich up in the foil.
• Put the sandwich on the grill, place a large baking sheet on top and weigh it down with a large cast-iron pan or 2 large cans of food. Grill for 5 minutes, remove the baking sheet and weight, flip the sandwich, weigh it down again and grill until the Swiss cheese has melted, about 5 minutes more.
• Unwrap the sandwich, cut into 4 pieces and serve immediately.

CUBAN GRILLED PORK (LECHON ASADO)

Steps:

• Prepare the marinade
• Mix all marinade ingredients in a bowl and let sit for 10 minutes.
• Marinate the pork
• If using a flavor injector (see cooking notes), strain half the marinade into a bowl, adding the strained-out garlic to the other half of the marinade. Use the injector to take in some strained marinade, pierce the pork with the tip of the needle, and inject it into the flesh. Do this all over the meat until the strained marinade has been used up.
• If you are not using a flavor injector, use a long, thin knife to create deep gashes all over the flesh and pour the marinade over the pork.
• Place the marinated pork in a deep bowl or container. Generously season the outside of the pork with salt and pour the remaining marinade all over it, spreading the onion rings all over the top.
• Cover well with plastic wrap and refrigerate for at least 1 hour or up to 24 hours.
• Boil the marinade for basting
• Remove the pork from the marinade and place it on a platter. Transfer the marinade to a saucepan, add the onions, and bring to a boil for 2 minutes. Remove from the heat and allow to cool. Place the boiled marinade and onions in a blender and puree until smooth. The marinade is now ready to use as a basting liquid.
• Grill the pork
• Before heating your grill, remove the pork from the refrigerator and bring to room temperature.
• Heat your grill to 550°F and close the lid. Wait at least 15 minutes before lowering the temperature to 300°F. Oil the grill grates with a vegetable oil-soaked paper towel held with a long pair of tongs.
• If your cut has the skin still attached, begin the cooking process with the skin side up (away from the direct heat).
• Grill your meat about 2 1/2 hours total. Turn the meat over once when you are one quarter through with the cooking time, again when you are halfway through, and once more when three-quarters of the cooking time has elapsed. The pork is ready when it reaches an internal temperature of 150°F on the grill (it will continue to cook when it's off the heat, raising the internal temperature to the desired 160°F).

ULTIMATE GRILLED CUBAN SANDWICH

Steps:

• Light your grill and set it up for direct medium-high heat.
• Combine all rub ingredients and whisk together.
• Combine mayonnaise and yellow mustard with 2 tablespoons of the Cuban rub, mix thoroughly.
• While grill preheats and the spread melds together, rinse off pork tenderloins with cold water. Trim off any visible silver skin and pat dry .
• Rub pork with very thin coat of oil and season entire surface with a light dusting of the rub.
• Place pork over direct medium heat on the grill, cooking for 12-15 minutes, turning every 1.5-2 minutes.
• Remove pork when internal temperature reaches 140° F. Close grill lid but don't turn it off.
• Baste pork with a light coat of oregano olive oil and let rest 5-10 minutes.
• Slice pork thinly.
• Apply a generous portion of the mayonnaise and seasoning mixture to the top bun and bottom of each sandwich roll and set aside.
• Assemble your sandwiches by layering slices of pork, ham, and cheese on the bottom bun. Place the assembled sandwiches in grill over indirect heat for about 4 minutes, or until the cheese melts.
• Remove from grill, top with pickle slices and your top bun, then slice and serve.

CUBAN PULLED PORK SANDWICHES

Steps:

• In a 6- or 7-qt. slow cooker, combine first 9 ingredients. Add pork; cook, covered, on low until tender, 8-10 hours. Remove roast; shred with 2 forks. In a large skillet, heat oil over medium-high heat. Cook meat in batches until lightly browned and crisp in spots. , Cut each loaf of bread in half lengthwise. If desired, spread mustard over cut sides of bread. Layer bottom halves of bread with pickles, pork, ham and cheese. Replace tops. Cut each loaf into 8 slices.

CUBAN-STYLE PORK SANDWICHES

Steps:

• Place onion wedges and broth in a 5-qt. slow cooker. In a small bowl, combine the parsley, 5 garlic cloves, vinegar, 1 tablespoon lemon juice, cumin, mustard, oregano, salt and pepper; rub over pork. Add to slow cooker. Cover and cook on low until meat is tender, 6-8 hours., Remove meat; let stand for 10 minutes before slicing. In another small bowl, combine the mayonnaise, mustard and remaining garlic and lemon juice; spread over buns. Layer bun bottoms with pork, cheese, sliced onion and pickles; replace tops., Cook on a panini maker or indoor grill until buns are browned and cheese is melted, 2-3 minutes.

GRILLED CUBAN SANDWICH (SANDWICH CUBANO)

Steps:

• Assemble the sandwich
• Spread 2 tablespoons of the butter on one half of the bread loaf and a thin layer of mustard on the other. Place 1 to 2 layers of ham, pork, cheese, and, finally, pickles on the buttered bread and top with the mustard-spread bread.
• Wrap the sandwich in foil
• Smear the remaining butter all over the outside of the sandwich and wrap it completely in aluminum foil.
• Press and grill the sandwich
• Heat your grill to high (550°F) and close the lid. Wait at least 15 minutes before lowering the heat to medium-high (450°F) and continuing.
• Before grilling the sandwich, press down on it with your hands to flatten it. Place the wrapped, flattened sandwich on the grill and top with a brick, grill press, or any other heavy, heat-resistant object. Close the lid and grill for 5 to 6 minutes per side.
• Remove the wrapped sandwich from the grill and take off the foil. Return the sandwich to the grill and grill for about 2 to 3 minutes per side, or until both pieces of bread are crispy and golden brown.
• Slice and serve
• Remove the sandwich from the grill and cut at an angle into small sandwich wedges (triangles). Place on a large platter and serve while still hot.

PRESSED CUBAN SANDWICH

Steps:

• 1. Roast the tenderloin, as directed. (usually 20 min per pound @ 375*), let it rest 10-15 minutes. Slice fairly thin, against the grain.
• 2. Split Hoagies and spread mayonnaise on the inside of both rolls. Put mustard on the inside of top roll.
• 3. Now assemble the swiss cheese on the bottom, then a layer of roasted pork, 3 slices of ham (folded to fit), 1 1/2 slices pickle, and then the top of hoagie.
• 4. Heat skillet to medium, or use a George Foreman (works very well). Spread outside of sandwich with butter or margarine, then grill until golden brown. If using a skillet, press sandwich with a spatula, then flip and press again.