Best Carolina Pulled Pork Sandwiches Recipes

NORTH CAROLINA-STYLE PULLED PORK SANDWICHES AND COLESLAW

Steps:

• Preheat the oven to 300 degrees. Mix together the salt, pepper, and paprika; sprinkle all over the pork and rub inches
• In a large skillet or Dutch oven, heat the oil over medium-high heat. Add the pork and cook, turning occasionally, until browned, 8 to 10 minutes. Transfer to a 24-inch-long sheet of heavy duty foil and double wrap the pork.
• Place the pork, skin side up, in a 9-by-13-inch baking dish; roast until tender, about 4 1/2 hours. Remove from the oven and carefully unwrap the top of the pork, revealing the skin. Increase the heat to 450 degrees and roast for 20 minutes more.
• Transfer the roast to a large bowl, along with any juices. Using two forks, shred the pork. Add the vinegars, sugar, and hot sauce; toss. Serve on the hamburger buns, topped with coleslaw (recipe follows), if using.
• For the coleslaw: In a medium bowl, whisk together the vinegars, sugar, hot sauce, crushed red pepper, salt, and pepper. Add the cabbage and toss. Let stand for 30 minutes, then toss and serve.

NORTH CAROLINA-STYLE BBQ PULLED-PORK SANDWICHES

Steps:

• Make small holes all over the pork shoulder with a thin sharp knife and stuff in garlic cloves. Rub the meat all over with the Memphis Shake; cover and refrigerate overnight.
• Prepare an outdoor grill with an indirect medium-hot fire with a mix of briquettes and hardwood charcoal in half of the grill. Set grate over coals. Place pork, skin side up, in an aluminum pan with about 1 1/2 cups water on the cooler side of the grate. Toss 1 cup of the soaked and drained wood chips onto the coals and cover the grill, making sure the lid's vents are directly over pork.
• When the coals cool to medium-low heat, preheat a chimney-full of hot briquettes and hardwood charcoal. Whenever smoke stops coming out of the vents, about every hour, add more hot coals and 1 cup of soaked and drained wood chips to the fire. The goal is to maintain a medium-heat, smoky fire (but don't worry if it is hotter when the coals are added and cooler while preheating the coals). Rotate the pork when you add coals so it cooks evenly. Cook the meat until an instant-read thermometer inserted into the thickest part of the pork registers 180 degrees F, about 6 hours.
• Set aside 1 quart of the North Carolina-Style Vinegar BBQ Sauce. Once the pork reaches 180 degrees F, begin mopping the entire surface of the meat every 20 minutes with some of the remaining sauce and the pan drippings. Continue to cook the pork, covering the grill between mopping, until an instant-read thermometer registers 200 degrees F, about 1 to 2 hours more.
• Transfer the pork to a cutting board and let rest for at least 15 minutes. Remove the outer skin and discard. Cut large chunks from the bone and shred, using 2 forks or your fingers, (when cool enough to touch) or chop. Toss with about 1 cup of the reserved barbecue sauce for every 3 cups of meat. Tuck the pork into the soft rolls and serve with pickles.
• Whisk paprika, brown sugar, oregano, garlic, ancho powder, salt, and celery salt in a small bowl. Store in an airtight container in a cool, dry place for up to 2 months.
• Heat the vinegar and sugar in a medium saucepan over medium heat until the sugar dissolves. Off the heat, stir in the ketchup, honey, salt, red pepper, and black pepper.

CAROLINA PULLED-PORK SANDWICHES

Steps:

• Make dry rub:
• Mix first 5 ingredients in small bowl to blend.
• Place pork, fat side up, on work surface. Cut each piece lengthwise in half. Place on large baking sheet. Sprinkle dry rub all over pork; press into pork. Cover with plastic; refrigerate at least 2 hours. (Can be made 1 day ahead. Keep chilled.)
• Make mop:
• Mix first 6 ingredients in medium bowl. Cover and refrigerate.
• Following manufacturer's instructions and using lump charcoal and 1/2 cup drained wood chips for smoker or 1 cup for barbecue, start fire and bring temperature of smoker or barbecue to 225°F. to 250°F. Place pork on rack in smoker or barbecue. Cover; cook until meat thermometer inserted into center of pork registers 165°F., turning pork and brushing with cold mop every 45 minutes, about 6 hours total. Add more charcoal as needed to maintain 225°F. to 250°F. temperature and more drained wood chips (1/2 cup for smoker or 1 cup for barbecue with each addition) to maintain smoke level.
• Transfer pork to clean rimmed baking sheet. Let stand until cool enough to handle. Shred into bite-size pieces. Mound on platter. Pour any juices from sheet over pork. (Can be made 1 day ahead. Transfer pork and any juices to baking dish. Cover with foil; chill. Before continuing, rewarm pork, covered, in 350°°F. oven about 30 minutes.)
• Divide pork among bottoms of buns. Drizzle lightly with barbecue sauce. Top with coleslaw. Cover with tops of buns.

SLOW-COOKER CAROLINA PULLED-PORK SANDWICHES

Steps:

• Spray 3- to 4-quart slow cooker with cooking spray. Trim fat from pork; place in cooker. In small bowl, mix brown sugar, salt, pepper and paprika; rub over pork.
• In medium bowl, mix remaining ingredients except rolls and coleslaw; pour into slow cooker.
• Cover; cook on Low heat setting 8 to 9 hours.
• Remove pork from cooker; place on cutting board. Shred pork with 2 forks; return to cooker and mix well.
• Using slotted spoon, spoon about 1/2 cup pork mixture, on bottom half of each roll. Top each with about 2 tablespoons coleslaw. Cover with top halves of rolls. Pork mixture can be kept warm on Low heat setting up to 2 hours; stir occasionally.

NORTH CAROLINA PULLED PORK BBQ SANDWICHES

Steps:

• BBQ Sauce:.
• In medium bowl, combine vinegar, brown sugar, red pepper flakes, Worcestershire sauce, salt and hot pepper sauce. Divide sauce into two portions; set aside.
• Pulled Pork:.
• At least 1 hour before grilling, soak wood chips in enough water to cover; drain before using. Rub meat with salt and black pepper. In a charcoal grill with a cover, place preheated coals around a drip pan for medium indirect heat. Add 1/2 inch hot water to drip pan. Sprinkle half of the drained wood chips over the coals. Place meat on grill rack over drip pan. Cover and grill about 4 hours or until meat is very tender. Add more preheated coals (use a hibachi or a metal chimney starter to preheat coals), wood chips and hot water every 1 to 1 1/2 hours. Remove meat from grill; cover with foil and let stand for 20-30 minutes. Using a fork, shred meat into long, thin strands. Pour sauce over shredded meat; toss to coat. Serve on toasted buns. If desired, top meat with coleslaw. Serve remaining sauce on the side.
• * Note: For gas grills, preheat and then turn off any burners directly below where the food will go. The heat circulates inside the grill, so turning the food is not necessary.

NORTH CAROLINA-STYLE PULLED PORK SANDWICHES

Steps:

• Preheat the oven to 300°. Mix together the salt, pepper and paprika; sprinkle all over the pork and rub in. In a large skillet or Dutch oven, heat the oil over medium-high heat. Add the pork and cook, turning occasionally, until browned, 8 to 10 minutes. Transfer to a 24-inch-long sheet of heavy-duty foil and double-wrap the pork. Place the pork, skin side up, in a 9-by-13-inch baking dish; roast until tender, about 4 1/2 hours. Remove from the oven and carefully unwrap the top of the pork, revealing the skin. Increase the heat to 450° and roast for 20 minutes more. Transfer the roast to a large bowl, along with any juices. Using two forks, shred the pork. Add the vinegars, sugar and hot sauce; toss. Serve on the hamburger buns, topped with coleslaw, if using.

NORTH CAROLINA STYLE PULLED PORK SANDWICHES

Steps:

• 1. Preheat the oven to 300. Mix together the salt, pepper and paprika; sprinkle all over the pork and rub in. 2. In a large skillet or Duch oven, heat the oil over medium-high heat. Add the pork and cook, turning occasionally, until browned, 8 to 10 minutes. Transfer to a 24-inch sheet of heavy-duty foil and double-wrap the pork. 3. Place the pork, skin side up, in a 9-by-13 inch baking dish; roast until tender, about 4 1/2 hours. Remove from the oven and carefully unwrap the top of the pork, revealing the skin. Increase the heat to 450 and roast for 20 minutes more. 4. Transfer the roast to a large bowl, along with any juices. Using two forks, shred the pork. Add the vinegars, sugar and hot sauces; toss. Serve on the hamburger buns topped with coleslaw, if using.

PULLED PORK SANDWICHES WITH WEST CAROLINA BARBECUE SAUCE

Steps:

• Make the sauce: in a saucepan over med-high heat, melt the butter and cook the onion, stirring occasionally, until translucent-4 to 5 minutes.
• Add in the remaining sauce ingredients; bring to a boil.
• Decrease heat and simmer for 10 minutes; set aside and let cool to room temperature.
• Let roast stand at room temperature for 20-30 minutes before grilling; season with salt and pepper.
• Grill roast, fat side up, over Indirect Medium heat until the internal temperature is between 185° and 190°, 3-4 hours.
• The meat should be so tender it pulls apart easily.
• Remove from grill, place on a platter, and loosely cover with foil; let rest for 20 minutes.
• Thinly slice, chop, or pull the pork meat into shreds with your fingers or two forks, discarding any large bits of fat.
• Moisten the meat with some of the sauce and mix well in a bowl.
• Grill the buns over Direct Medium heat until lightly toasted, about 30 seconds.
• Serve the pork warm on the buns with the remaining sauce on the side.

CAROLINA-STYLE PULLED PORK SANDWICHES

Steps:

• Coat the pork evenly on all sides with the Essence, rubbing the seasoning into the meat well with your hands. Wrap the pork in a double layer of plastic wrap and refrigerate for at least 4 hours and up to 2 days. Make a homemade smoker: Start by using a large roasting pan about 11 1/2-inches long by 15 inches wide. Place a piece of dampened paper towel laid out at both ends of the roasting pan. Place 4 small, 1/2-ounce glass bowls or other small heatproof bowls on top of the paper towels, 1 in each corner of the pan. Be sure that the bowls are inverted. Lay the wood chips in the center of the roasting pan. Place a second, smaller roasting pan, (about 10 by 13 1/2-inches), inside the larger pan. Lay 2 more pieces of moistened paper towels at either end of the small roasting pan. Place 4 more bowls inside the small roasting pan, 1 at each corner as before. Position a small baking sheet on top of the glass bowls inside of the small roasting pan. Place the pork on the baking sheet and position the "smoker" over 2 burners over medium-low heat (or over an indoor grill set at medium heat). Once the wood begins to smoke, wrap the entire roast and roasting pan with heavy-duty aluminum foil. Continue to cook the pork on the stovetop for 2 hours. Preheat the oven to 325 degrees F. After 2 hours, transfer the "smoker" to the oven and bake the roast until the pork is fall-off-the-bone tender, about 3 to 4 hours. Remove the pan from the oven and let rest, covered, for 1 hour. While the pork rests, make the barbecue sauce by combining the white wine vinegar, apple cider vinegar, sugar, red pepper flakes, and hot sauce in a non-reactive mixing bowl. Add salt and pepper, to taste. Set aside. Uncover the pork, and, using 2 forks, shred the meat. Discard any large pieces of fat. Place the meat in a large bowl and pour the barbecue sauce over the pork. Toss to combine.

PULLED PORK SANDWICHES WITH WEST CAROLINA BARBECUE SAUCE

Steps:

• To make the Sauce: In a small saucepan over medium-high heat, melt the butter and cook the onion, stirring occasionally, until translucent, 4 to 5 minutes. Add the rest of the sauce ingredients and bring to a boil. Reduce heat and simmer for 10 minutes more. Set aside and allow to cool to room temperature.Allow the roast to stand at room temperature for 20 to 30 minutes before grilling. Season with salt and pepper. Grill the roast, fat side up, over Indirect Medium heat until the internal temperature reaches between 185°F and 190°F, 3 to 4 hours. The meat should be so tender it pulls apart easily. Remove from the grill, place on a platter, and loosely cover with foil. Allow to rest for about 20 minutes.Thinly slice, chop, or "pull" the pork meat into shreds with your fingers or two forks, discarding any large bits of fat. Moisten the meat with some of the sauce and mix well in a bowl. Grill the buns over Direct Medium heat until lightly toasted, about 30 seconds. Serve the pulled pork warm on the buns with the remaining sauce on the side.From Weber's Big Book of Grilling. Copyright © 2001 Weber-Stephen Products Co. All rights reserved. First published by Chronicle Books LLC, San Francisco, California.