Best Timballo Spaghetti Casserole Recipes

TIMBALLO

Steps:

• For the base pasta layer: Bring a large pot of salted water to a boil. Cook the penne for 10 minutes. Then chill in an ice bath after cooking until cool to the touch. Drain and set aside in a large bowl.
• For the sauce: Heat a 12-inch cast-iron pan over medium-high heat and add the oil. Once, heated, add the onions, garlic, baharat, red chile flakes, fennel seeds and turmeric and cook for 5 minutes. Add the tomatoes and cook for another 15 minutes. Puree with an immersion blender if the tomato pieces are large. Season with salt. Add the sauce to the cooked penne pasta along with the Pecorino-Romano. Stir to combine and keep at room temperature.
• For the fregola layer: Bring a large pot of salted water to a boil. Cook the fregola pasta for 12 minutes scoop out to drain. Set aside in a large bowl. Add the asparagus to the boiling water and let cook until brightened in color, 2 to 3 minutes. Remove to a large plate and let sit until just cool to the touch. Add the peas to the boiling water and let cook until brightened in color, about 2 minutes. Drain and set aside in a large bowl.
• Cut the asparagus into 1-inch pieces and add to the bowl with the peas. Add the pesto and stir to combine. Add the fregola and stir to combine. Set aside.
• For the lasagna layer: Bring a large pot of salted water to a boil. Preheat a pizza oven or oven to broil.
• Boil the pasta sheets for 3 minutes and chill in ice water. Set aside.
• Put the peppers onto a sheet tray and put in the oven to char on all sides, about 10 minutes total, rotating as needed. Remove from the oven and put into a bowl. Cover with plastic wrap and allow to steam for 10 minutes. Once cool enough to handle, remove from the bowl and carefully remove most of the charred skin. Stem, seed and slice the red peppers into thick slices and set aside.
• Put a 12-inch cast-iron pan over medium-high heat and add the oil. Once heated, add the spinach, season with salt and toss to combine, allowing the spinach to wilt, about 3 minutes. Set aside.
• For the timballo assembly: Oil a 14-inch cast-iron pan. Add a 1-inch layer of base penne mixture (about 1/3 of the mixture) and flatten. Add half of the fregola/pea mixture and flatten again. Add a layer of the cooked and cooled lasagna sheets to cover. Cover with half of the wilted spinach, half of the roasted red pepper slices and half of the fresh mozzarella slices. Repeat all the layers, finishing with the base penne mixture and garnish with the Parmesan.
• Bake until golden brown and bubbly, about 20 minutes.

TIMBALLO

Steps:

• For meat sauce:
• Heat oil in a 12-inch heavy skillet over moderately high heat until hot but not smoking, then sauté sausage, breaking up lumps with a fork, until no longer pink, about 5 minutes. Add onion and bay leaf and sauté, stirring frequently, until onion begins to brown, 5 to 7 minutes. Add carrot, celery, and salt and sauté, stirring occasionally, until vegetables begin to soften, about 4 minutes. Add tomato paste and cook, stirring constantly, 1 minute, then add wine and deglaze by boiling, scraping up any brown bits, until most of liquid is evaporated, 1 to 2 minutes. Add tomato purée and sugar and boil, stirring frequently, until thickened, 8 to 10 minutes. Cool sauce and discard bay leaf.
• For pasta:
• Cook pasta in a 6- to 8-quart pot of boiling until al dente, then transfer with a skimmer to a colander to drain (do not rinse), reserving water in pot to cook chard. Cool pasta, spread in a baking pan, to warm.
• For chard in béchamel sauce:
• Add chard to pot and simmer, uncovered, until tender, 3 to 5 minutes, then transfer with skimmer to a bowl of ice and cold water. Drain chard and squeeze handfuls, then finely chop.
• Heat butter in a 1 1/2- to 2-quart heavy saucepan over moderate heat until foam subsides, then add garlic and cook, whisking, 1 minute. Add flour and cook, whisking, 1 minute, then add milk in a slow stream, whisking. Bring to a boil, whisking. Reduce heat and simmer, whisking occasionally, until sauce is slightly thickened, about 5 minutes. Stir in chard, salt, pepper, nutmeg, and 2 tablespoons Parmigiano, then remove pan from heat.
• Assemble and bake timballo:
• Put oven rack in lower third of oven and preheat oven to 375°F.
• Oil soufflé dish and line bottom with a round of parchment paper, then oil parchment. Cover bottom of dish with a single layer of pasta. Sprinkle 1/2 cup mozzarella and 3 tablespoons Parmigiano over pasta, then spoon half of meat sauce in an even layer over cheese. Arrange one third of remaining pasta over meat sauce in soufflé dish and top with all of chard, then another layer of pasta (about half of remainder). Sprinkle with remainder of cheeses, then spoon remaining meat sauce over cheese. Top with remaining pasta. (You may have pasta left over.) Cover pasta with an oiled round of parchment (oiled side down) and cover dish with foil.
• Bake in a in wide 6- to 8-quart pot until bubbling and a metal skewer or thin knife inserted in center of timballo comes out hot to the touch, about 1 hour. Remove soufflé dish from water bath and let stand, covered, 15 minutes. Remove foil and parchment and run a knife around edge of timballo to loosen, then invert a platter over soufflé dish and invert timballo onto platter. Remove soufflé dish and remaining parchment.

TIMBALLO GENOVESE

Steps:

• For the sauce: Heat a large Dutch oven over medium-high heat. Add the oil. Season the meat evenly with 1/2 teaspoon salt and add to the hot pan. Cook until the meat is deep brown on the first side, about 4 minutes. Flip and continue to cook until deep, dark brown, an additional 3 minutes on each side. Remove the meat to a plate.
• Reduce the heat to medium and add the onions and an additional 1/2 teaspoon salt. Stir with a wooden spoon, scraping up all the bits from the bottom and coating the onions in the oil from the pan. Cook the onions, stirring often, until deep golden brown, 25 to 30 minutes.
• Add the garlic, carrots and celery and cook until fragrant and soft, another 2 minutes. Clear a little space in the pan so you can see the bottom. Add the tomato paste to that spot and toast the paste, stirring often, until deep red, about 2 minutes. Stir the paste into the vegetables and deglaze with the Marsala. Simmer for 3 minutes to reduce slightly. Place the meat back into the pan and add 3 cups water to cover three-quarters of the way. Nestle the Parmesan rind into the sauce. Reduce the heat to maintain a gentle simmer. Cover with a lid just slightly ajar and simmer, stirring occasionally to prevent sticking, until slightly reduced and the onions are practically melted into the sauce, about 2 1/2 hours.
• Season with the remaining 1 teaspoon salt. Remove the piece of meat and the cheese rind. Discard the rind and save the beef for another use. Using a handheld immersion blender, pulse the sauce to even out the consistency. Stir in the butter until combined. Remove 1 1/2 cups of the sauce and reserve for the assembly.
• For the meatballs: Preheat the broiler to high.
• Mix together the milk, bread and egg with a fork in a medium bowl and let the mixture sit for 5 minutes to thicken. Stir in the Parmesan, oregano and salt. Using your hands, mix in the beef until just combined. With damp hands, scoop 1/2-teaspoon mounds and roll into uniform balls. Place on a rimmed baking sheet. Broil until browned, about 7 minutes. Set aside.
• Reduce the oven temperature to 350 degrees F.
• For the filling: Heat a small skillet over medium heat. Add the oil and bacon and cook, stirring often, until the bacon is crispy and browned, about 5 minutes. Pour off all but 1 tablespoon of the fat. Stir in the peas and salt and remove from the heat.
• For the assembly: Bring a large pot of water to a boil. Season well with salt. Add the pasta and cook for 2 minutes. Using tongs, remove the pasta from the water and add directly to the sauce in the Dutch oven. Sprinkle the bare pasta with 1 1/2 cups Parmesan and toss well with the sauce. Add 1/2 cup pasta water to loosen slightly and help the sauce coat the pasta, if needed.
• Using the tongs, place half of the sauced pasta in the bottom of a springform pan. Spread 1/2 cup of the reserved sauce on top of the pasta. Sprinkle with the smoked provolone. Follow with the pea mixture, then the meatballs. Sprinkle the meatballs with 1/2 cup Parmesan. Press down slightly to pack. Top with the remaining pasta and 1 cup reserved sauce. Press gently to compress. Top the pasta with the remaining 1 cup Parmesan.
• Place on a rimmed baking sheet and bake until golden brown on top, 50 to 60 minutes. Allow the timbale to rest for 30 minutes before running a knife around the edge and unmolding. Slice with a thin, sharp knife to serve.