Best Italian Sandwich Recipes

CHICAGO ITALIAN BEEF SANDWICH

Steps:

• Rub meat with dry ingredients, cover and refrigerate for 2 to 3 hours.
• Preheat oven to 275 degrees F.
• Add meat to a roasting pan with bacon fat, add onions and garlic, saute for 15 minutes, deglaze with wine, and add Worcestershire sauce, beef stock and bay leaves.
• Place roasting pan in the oven and cook for 3 hours, uncovered, or until an instant-read thermometer registers 135 degrees F in center. Remove, let cool, then slice very thin.
• Cool broth in roasting pan and remove the fat that rises to the top. Strain.
• Reheat the broth, and add the sliced meat. Place some meat on each toasted roll, ladle with some broth and top with giardiniera vegetables and red peppers.

CHICAGO-STYLE ITALIAN BEEF SANDWICH

Steps:

• For the pot roast: Position an oven rack in the center of the oven and preheat to 300 degrees F.
• Liberally sprinkle the entire roast with salt and pepper. Heat the vegetable oil in a Dutch oven over medium-high heat. Brown the roast on all sides until golden and caramelized, 5 to 7 minutes per side; reduce the heat if the fat begins to smoke. Transfer the roast to a plate and reduce the heat to medium.
• Add the onions and a pinch of salt and saute, stirring occasionally, until just beginning to brown, 8 to 10 minutes. Add the Italian seasoning, crushed red pepper and garlic and saute until fragrant, another minute. Deglaze with the red wine, scraping up the browned bits from the bottom of the pot. Simmer until reduced by about half, another 2 to 5 minutes. Add the stock and thyme and bring to a simmer. Adjust the seasoning of the liquid.
• Put the roast back in the pot with any accumulated juices and place in the oven, covered. Cook the roast, turning every 30 minutes and uncovering the pot for the last 30 minutes of cooking, until very tender, 3 to 3 1/2 hours. Transfer the roast to a cutting board and tent with foil. Increase the oven temperature to 350 degrees F for the peppers and bread.
• For the sweet peppers: Toss the pepper strips with the olive oil, granulated garlic and some salt and pepper on a baking sheet. Bake, stirring halfway through, until lighter in color and softened, about 45 minutes.
• Strain the pot roast jus through a fine-mesh strainer into a bowl and return to the pot. Bring to a simmer and simmer until reduced slightly, 5 to 10 minutes. Adjust the seasoning if necessary. Keep warm.
• Once the meat has cooled a bit, remove the twine. Pull the meat into smaller chunks and return to the reduced jus until ready to build the sandwiches.
• For the sandwich build: Rub the rolls with some of the giardiniera oil and toast in the oven until golden brown and crispy, 5 to 8 minutes.
• Place some beef on a roll, then some sweet peppers (with some of the oil they were cooked in), followed by some hot giardiniera. Pour a small dish of reduced jus. Quickly dunk the whole sandwich in the hot jus, then wrap in deli paper or parchment paper and wait for 2 to 3 minutes while the magic happens. Repeat with the remaining rolls and toppings. When ready, open up and eat!

CHICAGO-INSPIRED ITALIAN BEEF SANDWICH

Steps:

• Season beef with a pinch of salt and black pepper. Heat vegetable oil in a heavy pot over high heat. Cook and stir beef in hot oil until browned, 5 to 8 minutes.
• Stir garlic, vinegar, oregano, 1 1/2 teaspoons salt, thyme, rosemary, 1 teaspoon black pepper, bay leaf, and red pepper flakes into beef. Pour enough chicken broth into beef mixture to cover the meat by 1 inch and bring to a simmer.
• Cover pot with a lid, reduce heat to low, and simmer until meat is fork-tender, 1 to 1 1/2 hours.
• Transfer meat with a strainer or slotted spoon to a separate pot; pour about 1/4 cup of meat broth into pot. Use a wooden spoon to gently break meat into smaller chunks. Cover pot with a lid or aluminum foil and keep warm.
• Skim excess grease from top of broth remaining in the first pot; season with salt and pepper to taste. Cover pot with a lid or aluminum foil and keep broth warm.
• Lay halves of a roll out on a work surface and spoon 2 to 3 tablespoons meat broth over each half. Top bottom half of roll with a generous portion of meat and a spoonful of pickled vegetables. Place tops on sandwich. Repeat with remaining buns, broth, meat, and pickled vegetables to make 3 more sandwiches.
• Spoon hot meat broth into ramekins and top each ramekin with 1/2 teaspoon parsley. Serve sandwiches with hot broth for dipping.

TONY LUKE'S ITALIAN ROAST PORK SANDWICH (THE REAL DEAL)

Steps:

• Turn crock pot on high setting.
• If the roast comes in elastic-y netting remove the netting, but keep it intact, you'll be stuffing it back in later.
• Mix the next 6 ingredients in a bowl.
• Spread the pork roast out on a clean surface.
• If there are any large thick sections of meat, score them with a knife.
• Rub 3/4 of the mixture over all exposed surfaces.
• Roll the roast back up and place back in netting.
• (Or truss with kitchen twine if no netting was provided) Rub the remaining mixture on the outside of the roast.
• Place the roast in the crock pot and cook at high for 20 minutes.
• Turn down to low and cook at least 3 hours longer or until the pork is falling apart.
• Remove pork from truss or netting and shred into large chunks, removing any large pieces of fat that may be left.
• Return to juices which have accumulated in the crock pot.
• For the broccoli rabe: Wash thoroughly and cut about 1/2 inch off the bottom of the stems.
• Cut the florets off the top and set aside.
• Bring 3qts salted water to a rolling boil.
• Add broccoli rabe leaves and stems and cook about 1&1/2 minutes then add the florets and cook until tender, about 5-7 minutes.
• Remove broccoli from boiling water and drain, but reserve about 1/4- 1/2 cup of the cooking liquid.
• In a deep frying pan (which is cold) begin heat olive oil, red pepper flakes and garlic together over medium heat.
• Once the garlic begins to sauté, begin to time about two minutes (till very lightly browned) add drained broccoli.
• Sauté the broccoli rabe about 3-5 minutes longer and then add the cooking liquid from the pot.
• (This should look a little soupy).
• Assemble: Toast sliced roll if desired.
• Add provo to roll before hot meat. then the cheese can melt. After that top with broccoli rabe generously. manja!

CHICAGO JOHNNY'S ITALIAN BEEF SANDWICH RECIPE (CHICAGO STYLE BEEF)

Steps:

• Puree the following together in a food processor: garlic, olive oil, Italian seasoning, oregano, black pepper, sweet paprika, crushed red pepper, onion powder, granulated garlic, sea salt. Sear your roast in a hot pan, stovetop. Use a spatula to rub your pureed spices onto your roast. Put your rubbed roast & any juices from searing into a deep glass or metal dish & add 16 oz. of beef stock; place into a preheated 225 degree oven for 90-120 minutes, depending on the size of your roast. Put your roast & gravy into two separate dishes & refrigerate them overnight. Slice your roast as thin as you can without shaving it. Put your gravy into a pot & bring to a simmer; put your thinly sliced beef into the simmering gravy until cooked through; this process will only take moments. Compile your sandwich with any/or all of the following: provolone, mozzarella, Italian beef, Chicago Johnny's Giardiniera, sweet peppers*. Using tongs, grab your whole sandwich & "dip" it into your simmering gravy for a flavorful Italian beef. *To make sweet peppers, slice 2-3 green bell peppers & sauté in olive oil, 7-10 cloves garlic, 1 tea black pepper, 2 tea sea salt; cook until peppers just start to soften.

GRANDMA'S ITALIAN GRILLED CHEESE SANDWICH

Steps:

• Whisk eggs, milk, garlic powder, Italian seasoning, and Parmesan cheese together in a bowl.
• Place each American cheese slice between two pieces of bread to assemble 6 sandwiches.
• Dip both sides of each sandwich in egg mixture.
• Heat a non-stick frying pan over medium heat.
• Place dipped sandwiches in the hot frying pan; cook until golden brown and cheese is melted, about 3 minutes per side.

PORCHETTA - ITALIAN MARKETPLACE SLOW ROAST PULLED PORK SANDWICH

Steps:

• Lay the pork on a large chopping board and cover with cling film. With a rolling pin, mallet, or other suitable blunt object, pound the meat as close to an even 1" thickness that you can manage.
• Heat 2 tablespoons of the olive oil in a frying pan over a medium high. Add all of the chopped onion, half the minced garlic, half the fennel seeds, all of the rosemary and bay, half of the ground cloves, salt and pepper, and cook for 2 to 3 minutes, or until all the fragrance has been released from the herbs and spices. Transfer to a plate to cool.
• Spread and rub this mixture over and into the pork, then roll the meat up as tightly and neatly as you can. Tie with kitchen string at intervals.
• Mix the remaining ingredients (minced garlic, fennel seeds, ground cloves, olive oil) and rub it over the outside of the pork. Cover it with cling film and refrigerate 24 hours, or at least overnight.
• Remove the meat 40 minutes before cooking to allow it to return to room temperature. Meanwhile, preheat the oven to 150C/300F Take the cling film off the pork and place the pork joint in to a roasting tin.
• Cook the pork for 4 hours to 5 hours, until it is falling apart when you test it with a knife or fork. If the spices on the surface start to char too badly (a little blackness is a good thing), tent foil loosely over the roast. (I find I need to cover it for the last hour of cooking.).
• CROCK POT - at this stage, cook the pork in a crock pot for 4 to 5 hours on high, or on automatic for up to 8 hours.
• Remove from the oven and leave to rest at least 30 minutes to one hour. Slice, pull or shred the meat and serve in warmed ciabatta rolls.

ITALIAN SAUSAGE SANDWICH

Steps:

• Preheat the oven to 375°F.
• In a skillet brown sausage.
• Drain off the fat, stir in the sauce and olives, heat through.
• Split rolls lengthwise without cutting through opposite side.
• Hollow out buns slightly, halve cheese slices lengthwise.
• Place a piece of cheese on bottom half of each roll.
• Divide meat mixture evenly among the 4 rolls, top with onion and sweet peppers.
• Place another cheese slice on top and close the rolls.
• Wrap each sandwich in foil and seal, place on a baking sheet and bake the wrapped sandwiches in the oven for approx 15 minutes.
• Unwrap serve and enjoy!

ITALIAN GRILLED STEAK SANDWICH

Steps:

• Place first 4 ingredients in a large bowl or shallow dish. Add steak and turn to coat. Refrigerate, covered, 8 hours or overnight., Remove steak, discarding marinade. Grill steak, covered, over medium heat or broil 4 in. from heat until meat reaches desired doneness (for medium-rare, a thermometer should read 135°; medium, 140°), 6-8 minutes per side. Cool completely., Cut bread loaf horizontally in half. Hollow out both halves, leaving a 1/2-in. shell (save removed bread for another use). Cut steak across the grain into thin slices. In a bowl, toss tomatoes with green onions, olives, pepperoni, basil and 2 tablespoons dressing. In another bowl, toss arugula with remaining dressing. , Place half the arugula in bread bottom. Layer with steak, tomato mixture and remaining arugula; replace top. Wrap in foil; refrigerate at least 1 hour. Cut into wedges to serve.

ITALIAN HERO SANDWICH

Steps:

• Rinse the red onion under cold water, then transfer to a large bowl. Add the red wine vinegar, dried oregano and 1 teaspoon salt. Stir to combine and set aside.
• Arrange the rolls cut side up so they lie flat. Spread with a thin layer of mustard and/or mayonnaise, if using. Shingle the entire surface with the cheese, then the cured meats. Scatter an even layer of pickled peppers.
• Add the iceberg lettuce and olive oil to the onion-oregano mixture and toss until well coated. Season to taste with salt. Pile the lettuce on one side of the sandwich, then close the sandwich and press down lightly. If packing, wrap the sandwich tightly in parchment paper or foil, then cut in half crosswise. Sandwiches will keep for up to 4 hours refrigerated.

ITALIAN PORCHETTA SANDWICH

Steps:

• Preheat the oven to 275 degrees F.
• For the herb rub: Add the garlic, fennel seeds and red pepper flakes to a food processor and pulse until finely chopped. Add the oregano, rosemary and thyme and pulse into a rustic paste. Season with salt. Reserve 2 tablespoons of the rub for the mayonnaise spread.
• For the pork: Lay the pork belly on a cutting board, skin-side-up, and score the skin at 1-inch intervals, 1/2-inch deep with a sharp knife. Rotate the pork 90 degrees and score the skin again, to create a diamond pattern. Sprinkle generously with salt; be sure to get into all the crevices. Flip the pork over, sprinkle generously with salt, then rub the meat side with the herb rub. Roll the pork belly up as tightly as possible and tie it crosswise with butcher's twine at 2-inch intervals.
• Place the pork in a roasting pan fitted with a rack. Pour 1/2 cup water into the bottom of the pan. Roast the pork to an internal temperature of 150 degrees F, 2 1/2 to 3 hours. Check periodically to ensure there is still some liquid in the bottom of the pan and add a little water to prevent scorching. Baste the pork belly with pan drippings a couple of times during cooking.
• Once the pork reaches 150 degrees F, raise the oven to 475 degrees F and continue roasting until the skin is super crispy, 30 to 40 minutes. For even browning, flip the pork halfway through the second roasting period.
• Transfer the porchetta to a cutting board and let rest for 20 to 30 minutes.
• Remove the rack from the roasting pan and pour off all but 3 tablespoons of the pan drippings. Set the roasting pan on the stovetop over medium heat. Add the onions and saute until lightly caramelized, about 15 minutes. Season with salt and pepper.
• For the mayonnaise spread: Mix together the mayonnaise, capers, parsley, lemon zest and juice and the reserved herb rub. Season with salt and pepper.
• Cut the porchetta into 1/4-inch-thick slices.
• To assemble the sandwich: Slather both halves of a ciabatta roll with mayonnaise spread. Layer the bottom half with slices of porchetta and top with caramelized onions and arugula.

ITALIAN DELI SUBMARINE SANDWICH

Steps:

• Slice the loaf of bread in half lengthwise,.
• Spread both sides with mayo or salad dressing.
• Layer the bottom half of bread starting with sliced tomatoes, then prosciutto, then salami, then cheddar slices, then ham, then provolone cheese slices, then sliced dill pickles.
• Top with shredded lettuce then sprinkle with black pepper.
• Top with the pickled peppers.
• Spoon the Italian vinaigrette over the filling.
• Cover with the other top half of bread.
• Press down firmly with your hand.
• Slice as desired.

ITALIAN HERO SANDWICH

Steps:

• In a small bowl, combine the vinegar, oregano, mustard, salt and pepper.
• Stir to mix well.
• Whisk in the olive oil until incorporated.
• On a work surface, lay out 3 long pieces of plastic wrap, placing them side by side and slightly overlapping.
• Place the bottom half of the loaf over the wrap.
• Spread the pepperoncini and cherry peppers over the bread.
• Scatter evenly with the lettuce and layer with the tomatoes.
• Drizzle with a few tablespoons of the dressing.
• Layer the meats, one at a time, over the tomatoes, making sure to distribute them evenly.
• Top with a layer of provolone cheese.
• Drizzle the remaining dressing over the cut side of the top of the loaf.
• Place on the layered sandwich and enclose in the plastic.
• Refrigerate for at least 1 hour or for up to 4 hours to develop the flavors.
• To serve, unwrap the sandwich and slice into large pieces about 3 to 4 inches wide.

ITALIAN PEPPER & EGG SANDWICH

Steps:

• In large skillet add olive oil and garlic and saute on low-med until garlic is golden, (do not burn). Add peppers, season with salt and pepper, stir to coat peppers with oil. Continue cooking on low-med heat, stirring frequently, until peppers are soft. Raise heat to med-high and add eggs, stirring well to coat egg onto peppers. Cook eggs throughly, making sure not to burn. Sprinkle with cheese and red pepper serve on roll and add gardinera.

ITALIAN PORK SANDWICH WITH BROCCOLI RABE AND SHARP PROVOLONE

Steps:

• Preheat the oven to 400 degrees F and a grill pan over medium-high heat.
• Sprinkle the pork tenderloin generously with salt. Coat the preheated grill pan with oil. Sear the tenderloin on all sides until golden brown and internal temperature reaches 145 F, about 10 minutes. Remove from heat and allow to rest for 5 to 7 minutes. Cut into 1/4-inch-thick slices.
• Toast the rolls, cut side-down, on the grill pan allowing the bread to crisp up and soak up the flavor from the pork. Remove from heat and set aside.
• Meanwhile, whisk together the mayonnaise, Parmesan, Calabrian chiles and vinegar in a small bowl.
• Bring a large pot of salted water to a boil. Fill a large bowl with salted water and ice. Add the broccoli rabe to the boiling water and cook until just tender, about 1 minute. Remove from boiling water and drop immediately into the ice bath. Once cool, remove, drain and roughly chop.
• Coat a large skillet with oil and heat. Add the garlic and cook, stirring, until just soft, about 1 minute. Add the broccoli rabe, season with salt and saute until heated through.
• Build the sandwiches: Spread the mayonnaise-chile mixture on the toasted sides of a roll. Top the bottom of the roll with half the pork, broccoli rabe and provolone cheese. Top with top piece of the roll and transfer to a baking tray. Build the second sandwich with the remaining ingredients. Bake just until cheese melts, about 3 minutes.
• Slice each sandwich in half and serve!

CHICAGO-STYLE ITALIAN BEEF SANDWICH

Steps:

• Cut notches all over the roast with a sharp knife. Rub with Greek seasoning, pepper, salt, and garlic. Cover and refrigerate for at least 4 hours.
• Bring roast to room temperature before cooking, about 1 hour. Tie up roast with kitchen twine so it will hold its shape while roasting.
• Preheat the oven to 375 degrees F (190 degrees C).
• Mix beef broth and bouillon granules together in a roasting pan. Place roast on a rack above the broth so drippings will fall into the broth.
• Bake in the preheated oven until tender, about 1 1/2 hours. An instant-read thermometer inserted into the center should read 140 degrees F (60 degrees C). Tent with foil and let cool for 20 minutes.
• Pour broth into a saucepan. Bring to a simmer. Slice roast very thinly; dunk slices in the hot au jus and stuff into Italian rolls. Top with giardiniera. Ladle more au jus over each sandwich.

PORCHETTA - ITALIAN MARKETPLACE PULLED PORK SANDWICH (CROCK POT)

Steps:

• Rub the roast all over with the olive oil, then rub with the seasonings. Place roast in bottom of crock pot, and top with the bay leaves and chopped onion.
• Cover and cook on HIGH for 1 hour, then reduce heat to LOW and cook 10-12 hours more until meat is falling apart, yet tender, and done.
• Remove to a large cutting board and let cool slightly, then use two forks to pull apart the meat into chunks, discarding the bay leaves.
• Stuff into warmed and buttered Italian ciabatta rolls, and dig in!

ITALIAN SANDWICH COOKIES

Steps:

• Preheat the oven to 375 degrees F.
• In a mixer on medium speed, cream together the butter, sugar and salt until very fluffy, about 4 minutes. Add the vanilla and eggs and continue to beat very well for an additional 4 minutes, scraping down the sides at least once. Turn the mixer on low speed and add the flour and baking powder, and mix until just combined.
• Put the dough into a pastry bag or cookie press fitted with a star tip. On an ungreased cookie sheet, pipe cookies in 2-inch lines, spaced at least 1 inch apart. Place in the freezer for 5 minutes (this will help them retain their shape when baking).
• Bake until golden brown, 15 minutes. Let cool on the cookie sheets 3 minutes, then transfer to wire racks to cool completely. Spread a little more than half a teaspoon of jam on half of the cookies, then top with the remaining cookies to make sandwiches. Place in the freezer for another 5 minutes to help set while you prepare the chocolate.
• Toss together the chocolate and the oil and place in a microwave-safe mug. Microwave in 30-second increments, stirring occasionally, until completely melted. Put the rainbow sprinkles onto a plate.
• Working quickly, dip the cookies halfway into the chocolate, then roll in the sprinkles. Place finished cookies on a tray lined with either wax or parchment paper to set completely. Cookies will keep in an airtight container for about 1 week.

PRESSED ITALIAN PICNIC SANDWICH WITH OLIVE RELISH

Steps:

• Stir together the celery, garlic, olives, parsley, olive oil and Italian seasoning in a medium bowl.
• Put the bottom half of the ciabatta on a work surface. Arrange half of the cheese on the bread, then top with the salami, turkey, ham and mortadella. Top the meat with the remaining cheese and the olive relish. Cover the sandwich with the top of the ciabatta.
• Wrap the sandwich tightly with plastic wrap and place it on a baking sheet. Place another baking sheet on top of the sandwich and weigh it down with a few large cans or a heavy skillet. Refrigerate the sandwich for at least 4 hours and up to 8.
• When ready to serve, unwrap the sandwich and cut into 6 to 8 pieces

ITALIAN EGG SANDWICH

Steps:

• Heat 2 teaspoons of oil in a heavy small skillet over medium heat. Crack the egg into the skillet. Sprinkle with salt and pepper. Cover and cook until the white is firm and the yolk is almost set, about 4 minutes. Season with salt.
• Meanwhile, toast the bread until golden brown. Rub the garlic over the toast. Sprinkle with the Parmesan. Spoon the drained marinara sauce over the Parmesan. Top with the egg. Place the open-faced sandwich on a plate and serve.
• In a large casserole pot, heat oil over medium high heat. Add onion and garlic and saute until soft and translucent, about 2 minutes. Add celery and carrots and season with salt and pepper. Saute until all the vegetables are soft, about 5 minutes. Add tomatoes, basil, and bay leaves and simmer covered on low heat for 1 hour or until thick. Remove bay leaves and check for seasoning. If sauce still tastes acidic, add unsalted butter, 1 tablespoon at a time to round out the flavors.
• Add half the tomato sauce into the bowl of a food processor. Process until smooth. Continue with remaining tomato sauce.
• If not using all the sauce, allow it to cool completely and pour 1 to 2 cup portions into freezer plastic bags. This will freeze up to 6 months.