Best Carolina Smoked Pork Recipes

SOUTH CAROLINA SMOKED PORK SHOULDER WITH MUSTARD SAUCE

Steps:

• Make the rub: add the mustard, paprika, salt, peppers, garlic powder, onion powder, and cayenne in a bowl; stir to mix.
• Sprinkle rub all over the pork, patting it onto the meat with your fingertips; let the pork cure at room temperature while you make the mop sauce.
• Mop sauce: combine the vinegar, mustard, salt, and pepper in a large mixing bowl; add in ½ cup water and whisk until salt dissolves.
• Set up grill for indirect grilling and preheat to medium-low-for a gas grill, place all the wood chips in the smoker box and run the grill on high until you see smoke, then decrease heat to medium low.
• When ready to cook, place the pork, skin side up, in the center of the hot grate, over the drip pan and away from the heat, and cover the grill.
• Cook the pork until darkly browned on the outside and very tender inside, 4-6 hours.
• Test for doneness with an instant read thermometer; the internal temperature should be about 195°; if the pork starts to brown too much, cover it loosely with foil.
• Every hour, for the first 4 hours, swab the pork with some of the mop sauce, using a barbecue mop or basting brush.
• Make the mustard barbecue sauce: melt the butter in a saucepan over medium heat; add in onion and garlic; cook until soft but not brown, about 3 minutes.
• Stir in the mustard, brown sugar, vinegar, and hot sauce; add ½ cup of water; let sauce simmer, uncovered, until thick and richly flavored, 6-10 minutes.
• Taste for seasoning, adding more hot sauce as needed and seasoning with salt and pepper to taste.
• Let the sauce cool to room temperature before serving.
• When the pork is done, transfer the cooked pork to a cutting board, cover it loosely with foil, and let it rest for 20 minutes.
• You could pull the pork or chop the pork, but Steven likes to thinly slice it across the grain.
• Place the pork slices in a foil pan if you are not quite ready to serve, cover the pan with foil and place it on a warm, not hot, grill or in an oven turned on low.
• To serve: brush the buns with melted butter and lightly toast them on the grill; load each bun with sliced pork and slather with mustard sauce.
• Top the pork and sauce with pickles and serve at once.

CAROLINA SMOKED PORK

Steps:

• Preheat smoker to 250 F. Place pork butt in the center of the cooking grate, fat-side down. Cover and smoke 8 hours, undisturbed. Check smoker temperature hourly; add charcoal and use vents as needed to maintain a temperature of 250 F through the duration of cooking.
• Make Carolina BBQ Sauce: In a mixing bowl combine sugar, black pepper, chili powder, crushed red pepper, and hot sauce to make a paste. Add the Sweet BBQ Pit Sauce, followed by vinegar; stir well to combine. The final consistency should be quite fluid, rather than thick. Makes about 2 cups of Carolina BBQ Sauce. (Store in a covered container at room temperature for several months.)
• Check for doneness by placing a digital thermometer into the center of the pork, avoiding contact with the bone. Temperature should register 170 F. Use heat-proof gloves to remove pork to a large cutting board on a flat work surface. Chop the pork: As you chop, the pork will cool, so plan on doing this as the last step before serving. The meat should be tender and falling apart. Pull the bone out of the meat: it should come away smoothly, with no meat clinging to it. Discard bone. Pick through the meat and set aside any bits that you don't want to include in the final dish, such as the barky exterior or excess fat. (You may opt to include everything: Pitmaster Jones says the final mix is up to you!)
• Using one cleaver, begin to chop the meat, using your free hand to carefully steady the pork butt. When the meat is in large chunks, use both cleavers at the same time to finish chopping. Use the cleavers to toss the meat on the board as you go; repeat the chopping-tossing process until the meat is bite-size and well mixed. Drizzle a small amount of Carolina BBQ Sauce on top of the meat; continue chopping and stirring to combine. Add more sauce to taste: the goal is to lightly complement the smoky flavor of the pork without overwhelming it. Makes about 7 lbs chopped pork. (Sam Jones's serving suggestion: Cool leftover pork in the fridge, then serve as a sandwich on white bread with mayonnaise.)